Product ID:YELLOW SUBMARINE, RFY-505-S9
MSDS Date:06/26/1992
FSC:8010
NIIN:00N038819
MSDS Number: BRGCR

OBRIEN CORP

450 EAST GRAND AVE
SOUTH SAN FRANCISCO, CA 94080
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 415-761-2300

Cage: IO230

OBRIEN CORP

SOUTH SAN FRANCISCO, CA 94080 US

Telephone: 415-761-2300

Cage: IO230

0.01.

CAS: 25036-25-3

Fraction By Weight: 30%

SILICON DIOXIDE, AMORPHOUS; (SILICA, AMORPHOUS FUMED). VP

CAS: 7631-86-9

Fraction By Weight: <5%

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

BARIUM SULFATE

CAS: 7727-43-7

RTECS: CR0600000

Fraction By Weight: 10%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

9500

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 20%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

THAT INHAL EXPOS TO HIGH LEVS (250 MG/M3) OF

RTECS: 9999999ZZ

RESPONSE OCCUR AT LOWER EXPOS LEVS & MAY BE DUE TO

RTECS: 9999999ZZ

MECHANISMS. THE RELEVANCE OF THIS DATA TO HUMANS IS

RTECS: 9999999ZZ

NUISANCE DUST

Fraction By Weight: 100%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE:POSS IRRIT. INHAL:MAY CAUSE
HDCH & RESP IRRIT. SKIN: POSS IRRIT/SENSIT. ING 2:INGEST: LOW ORDER
OF TOX.POSS DEPRESS OF CNS. INHAL:IRRIT, BUT NOT LIKELY ROUTE OF
EXPOS DUE TO VERY LOW VOLATI LITY. EYE:SEV IRRIT & POSS DMG.SKIN:
MOD-SEV IRRIT. POSS ALLERGIC SKIN RXN IN SUSCEPTIBLE INDIV. ING3:
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: IRRIT TO EYES, NOSE & UPPER RESP
TRACT. ING 4:INHAL OF DUSTS CONTAINING BARIUM SULFATE MAY BE IRRIT
TO RESP TRACT. CONT W/EYES MAY ALSO CAUSE IRRIT.ING 5:INGEST: LOW
ORAL TOX. NO TOX EFTS DU E TO INGEST ARE DESCRIBED IN LITERATURE.
INHAL: IRRIT TO UPPER RESP TRACT. EYE: IRRIT. CHRONIC: ING 2:IN
VITRO (SUPDAT)
Medical Cond Aggravated by Exposure:EPOXY RESIN: MAY AGGRAVATE EXISTING
SKIN CONDITIONS, A DERMAL ALLERGEN.

First Aid:INGESTION: DRINK 1-2 GLASSES OF WATER & INDUCE VOMITING BY
PLACING FINGER AT BACK OF THROAT. CONSULT PHYSICIAN OR POISON
CONTROL CENTER IMMEDIATELY. INHALATION: REMOVE FROM AREA TO FRESH
AIR. EYE: IMM EDIATELY BEGIN FLUSHING WITH COOL WATER, OCCASIONALLY
LIFTING LIDS TO ENSURE THOROUGH RINSING. CONTINUE FOR AT LEAST 15
MINS. WHILE FLUSHING EYES, SEND FOR MED ASSIST. SKIN: WASH THORO
W/SOAP & WATER.

Flash Point:>600F,>316C
Lower Limits:40 G/M3 AIR
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG, DRY
SAND.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DUST CLOUD OF 40 GRAMS PER CUBIC METER
CAN BE IGNITED BY SPARK OF 20 MILLIJOULES.

Spill Release Procedures:SWEEP UP CAREFULLY OR USE EXPLOSION-PROOF
VACUUM CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP ALL EQUIPMENT CLEAN AND PROPERLY
GROUNDED TO AVOID STATIC ELECTRICITY BUILD-UP. KEEP WORK AREAS FREE
OF DUST THROUGH ADEQUATE VENTILATION.
Other Precautions:AVOID PROLONGED CONTACT WITH SKIN. DO NOT INGEST.
KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:USE A NIOSH/MSHA APPROVED PROPERLY FITTED
MECHANICAL RESPIRATOR OR MASK TO AVOID BREATHING DUST. CAREFULLY
FOLLOW RESPIRATOR MANUFACTURER'S INSTRUCTIONS FOR USE.
Ventilation:PROVIDE SUFF VENT IN VOL AND PATTERN TO KEEP AIR CONTAM
CONCENTRATION BELOW APPLICABLE OSHA PEL/ACGIH'S TLV TWA LIMIT.
Protective Gloves:SYNTHETIC RUBBER GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:PROTECTIVE OVERALLS RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING.
Supplemental Safety and Health
EFTS OF OVEREXP: LAB STUDIES HAVE SHOWN THAT SOME EPOXY RESINS HAVE
MUTAGENIC CAPABILITIES. ALL EPOXY RESINS SHOULD BE TREATED AS
POTNTL MUTAGENS. ING 3:CURRENTLY BEING REVIEWED BY IARC. NO CHRONIC
HL TH HAZS ARE KNOWN. ING 4:PRLNGD EXPOS COULD CAUSE BENIGN
PNEUMOCONIOSIS CALLED BARITOSIS. ING 5:LAB STUDIES SHOW (ING 6)

Vapor Pres:SEE INGS
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:STATIC ELECTRICAL CHARGES.
Hazardous Decomposition Products:MAY PRODUCE FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE
AND NO*2.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.